Small bale hay

Latest Articles

Small bale hay
Page 1, 2 Next

Downsizer Forum Index -> Land Management

Author

Message

Nick

Joined: 02 Nov 2004
Posts: 34535
Location: Hereford

Posted: Thu Jul 14, 16 7:06 pm Post subject: Small bale hay
Can the house reassure me that once baled, hay won't come to much harm if it sits in the field for a couple of days with the odd light shower? I'm assuming it'll continue to dry with only the surface getting damp and then drying in the wind and sun? Looks like it might be done the moment I go away for two days at work. And the forecast shows light showers.

dpack

Joined: 02 Jul 2005
Posts: 46247
Location: yes

Posted: Thu Jul 14, 16 7:52 pm Post subject:
should be ok ,just be sure to collect and stack it after a drying phase. tis years since i have been involved in hay making but i seem to recall that small bales are quite well "thatched" against a bit of rain

Slim

Joined: 05 Mar 2006
Posts: 6612
Location: New England (In the US of A)

Posted: Thu Jul 14, 16 8:58 pm Post subject:

Probably best to lay them so the rain hits the hay "lengthwise" and not the end where it may flow in better. This would also keep those ends from wicking moisture up from the ground, so that only the very bottom layer and top layer get damp (hopefully)

I would still monitor the bales closely before storage. It all depends on your system and your equipment. Can you put a loosely filled wagon under cover somewhere to dry out again before tight stacking?

Is this hay for feed, or just meant to be mulch? After a few days of rains it won't be much value for feed, except maybe the very core of the bale

I just googled around since I didn't have a good source of the top of my head, but here's this: https://www.extension.umn.edu/agriculture/forages/utilization/preserving-the-value-of-dry-stored-hay/

Quote:

Dry matter losses caused by the combination of soil moisture and precipitation can be fairly large. For example, in Oklahoma, researchers found 13.1% dry matter loss for uncovered storage on the ground versus 2% loss for covered storage on pallets. Wisconsin researchers found 10.9% loss for uncovered storage on the ground versus 4.6% in a barn. In the Morris study, average dry matter losses in the uncovered piles on sod were 11.2% versus 2.3% in the barn. It appears that for eight to nine months of storage, you can expect a 6 to 11 percentage unit advantage by keeping bales off wet ground and under cover.

Besides losing dry matter, uncovered hay also loses quality as determined by nutritional analysis and by appearance. The loss in dry matter reduces weight available for sale and the loss in quality can have a large impact on animal performance and on hay value. For example, in our study at Morris, the internal parts of bales stored in the shed had a relative feed value (RFV) of 133 and the bottom six inches of the bales at the bottom of the pile had an RFV of 106. The internal parts of bales stored uncovered, outside on sod had an RFV of 114 and the external parts of the bales had RFVs ranging from 55 to 107.

Ty Gwyn

Joined: 22 Sep 2010
Posts: 4613
Location: Lampeter

Posted: Thu Jul 14, 16 9:01 pm Post subject:
Not recommended for small bales,fine for round bales.

Slim

Joined: 05 Mar 2006
Posts: 6612
Location: New England (In the US of A)

Posted: Thu Jul 14, 16 9:02 pm Post subject:

Ty Gwyn wrote:

Not recommended for small bales,fine for round bales.

Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

Ty Gwyn

Joined: 22 Sep 2010
Posts: 4613
Location: Lampeter

Posted: Thu Jul 14, 16 9:04 pm Post subject:

Slim wrote:

Ty Gwyn wrote:

Not recommended for small bales,fine for round bales.

Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.

Slim

Joined: 05 Mar 2006
Posts: 6612
Location: New England (In the US of A)

Posted: Thu Jul 14, 16 9:11 pm Post subject:

Ty Gwyn wrote:

Slim wrote:

Ty Gwyn wrote:

Not recommended for small bales,fine for round bales.

Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.

Nobody wants a barn fire, but at that point they were wetter than you were hoping for anyway and you're losing quality there as well. (not that weather is likely to cooperate with anybody during haymaking......)

Quote:

Storing hay inside a well ventilated barn will result in the least amount of loss. Humid regions... are good candidates for inside bale storage. Humid areas are also prone to bales being too wet at time of harvest. Bales too high in moisture can heat and catch fire. Thus, tightly packing bales into a barn can end with the loss of the shed if a bale catches fire.

Quote:

Storing hay can be improved several ways. If you do plan to store hay inside, invest in a hay moisture probe that will help you determine if hay if fit to pack into a barn with little risk of fire. If you plan to store hay outside, improve the drainage of the area. Run bale rows up and down a sloping area. You can stack bales on pallets or railroad ties. You may look into a layer of coarse rock that will keep bale to soil contact at a minimum. Make sure bales are not touching and avoid stacking bales outside without tarping. Tarps are a lower cost investment than sheds. If tarps are secured properly and the bottom of the bale is kept dry, expect big improvements in bale storage. Keeping moisture off and away from bales will help reduce hay storage losses.

From: https://www.cattlenetwork.com/advice-and-tips/stockerpasturerangeland/storing-hay-properly

Slim

Joined: 05 Mar 2006
Posts: 6612
Location: New England (In the US of A)

Posted: Thu Jul 14, 16 9:17 pm Post subject:
Here's a nice page on square bales and rain: https://www.afia.org.au/index.php/fodder-care/hay-factsheets/making-quality-hay/143-managing-hay-after-it-rains

Ty Gwyn

Joined: 22 Sep 2010
Posts: 4613
Location: Lampeter

Posted: Thu Jul 14, 16 10:13 pm Post subject:

Slim wrote:

Ty Gwyn wrote:

Slim wrote:

Ty Gwyn wrote:

Not recommended for small bales,fine for round bales.

Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.

Quote:

From: https://www.cattlenetwork.com/advice-and-tips/stockerpasturerangeland/storing-hay-properly

Ty Gwyn

Joined: 22 Sep 2010
Posts: 4613
Location: Lampeter

Posted: Thu Jul 14, 16 10:17 pm Post subject:

[quote="Ty Gwyn:1464928"][quote="Slim:1464924"]

Ty Gwyn wrote:

Slim wrote:

Ty Gwyn wrote:

Not recommended for small bales,fine for round bales.

Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.

dpack

Joined: 02 Jul 2005
Posts: 46247
Location: yes

Posted: Thu Jul 14, 16 10:48 pm Post subject:
having read their wise words im wondering if wilby was being optimistic after badly timed rain as the stuff had just been baled, tis close on 50 yrs ago he was pretty chuffed to have a baler rather than a fork and cart .

Nick

Joined: 02 Nov 2004
Posts: 34535
Location: Hereford

Posted: Fri Jul 15, 16 7:51 am Post subject:

Thanks. I think the answer will be what will be, will be. I've no choice in work and no control over the weather.

It's food, but only for horses and we have a massive excess*, so they can just eat more. Or starve. I'm easy.

As for tools, I've a teenager or two and a small trailer. They'll be stacked in a series of small sheds on pallets.

Sun through Wednesday would be the perfect answer.

*of both hay, and arguably, horses.

Slim

Joined: 05 Mar 2006
Posts: 6612
Location: New England (In the US of A)

Posted: Fri Jul 15, 16 11:30 am Post subject:

Ty Gwyn wrote:

Slim wrote:

Ty Gwyn wrote:

Slim wrote:

Ty Gwyn wrote:

Not recommended for small bales,fine for round bales.

Even that's not great if you can help it. Something like 30% of the bale is in the outer 6 inches which where you lose your quality and dry matter.....

If you store round bales to soon,you have a danger of a fire,
And lose all your dry matter.

I take it you have handled a lot of big bale hay?

Nope, I'm more veggies background and have been learning about forage quality, etc over the past few years. More of an academic than a practitioner these days. Sorry if I have a tone of more experience than I should!

I agree that a barn fire is worse than quality and dry matter loss! I'm just pointing out that if your bales are at risk of spontaneous combustion than they were baled wetter than you would be aiming for. (Baleage is a totally different story, and probably what I would be trying to do if I were feeding cows/sheep)

dpack

Joined: 02 Jul 2005
Posts: 46247
Location: yes

Posted: Fri Jul 15, 16 11:54 am Post subject:

Nick wrote:

if you have teenagers and a tarp perhaps making a tarp sandwich of them as soon as they emerge from the bailer would avoid them getting wet before there is chance to move and stack them properly.

Slim

Joined: 05 Mar 2006
Posts: 6612
Location: New England (In the US of A)

Posted: Fri Jul 15, 16 12:02 pm Post subject:
Shouldn't the teenagers be following the baler and picking up the bales anyway?

	Downsizer Forum Index -> Land Management	All times are GMT Page 1, 2 Next
Page 1 of 2

View Latest Posts